Current issue
Online first
Archive
About the Journal
Aims and scope
Publisher and Editorial
Advertising policy
For Authors
Paper review procedures
Procedures protecting authentic authorship of papers
Paper preparation manual
Plagiarism check
Publication ethics
Reviewers
APC
Editorial and Scientific Board
Contact
Reviewers
Comparison of pollutant concentrations and engine operating parameters during cold start with petrol and LPG
1
Environment Protection Centre, Motor Transport Institute, Poland
2
Lublin University of Technolog, Lublin University of Technology, Poland
3
Directorate, Motor Transport Institute, Poland
Submission date: 2025-05-16
Final revision date: 2025-09-12
Acceptance date: 2026-01-02
Online publication date: 2026-03-05
Corresponding author
KEYWORDS
TOPICS
ABSTRACT
The cold start of an ICE generates conditions conducive to intensive pollutant emission and reduced thermal efficiency. This study compared the concentrations of selected exhaust components and engine operating parameters during the cold start phase of a dual-fuel vehicle powered by petrol and LPG. The tests were conducted on a chassis dynamometer under identical ambient and load conditions, utilizing a repeatable homologation test. The analysis included HC, CH₄, and NOx concentrations, which were recorded simultaneously with the internal combustion engine's operating parameters: rotational speed, coolant temperature, throttle position, and load. The collected data enabled the development of mathematical models representing the relationships between the dynamics of the start process and pollutant concentrations. The results indicate significant differences in the start characteristics for individual fuels; in particular, LPG exhibits a distinct emission profile during the early phase of engine operation. Conclusions can serve as the basis for designing start control strategies in dual-fuel vehicles, considering environmental requirements and the further development of emission control systems.
REFERENCES (55)
1.
Adam TW, Astorga C, Clairotte M, Duane M, Elsasser M, Krasenbrink A et al. Chemical analysis and ozone formation potential of exhaust from dual-fuel (liquefied petroleum gas/gasoline) light duty vehicles. Atmos Environ. 2011;45:2842-2848. https://doi.org/10.1016/j.atmo....
2.
Appel D, Hagen FP, Wagner U, Koch T, Bockhorn H, Trimis D. Influence of low ambient temperatures on the exhaust gas and deposit composition of gasoline engines. ASME 2020 Internal Combustion Engine Division Fall Technical Conference, Virtual, Online: American Society of Mechanical Engineers. 2020:V001T04A003. https://doi.org/10.1115/ICEF20....
3.
Bielaczyc P, Szczotka A, Woodburn J. The effect of a low ambient temperature on the cold-start emissions and fuel consumption of passenger cars. Proc Inst Mech Eng Part D-J Automob Eng. 2011;225:1253-1264. https://doi.org/10.1177/095440....
4.
Çinar C, Şahin F, Can Ö, Uyumaz A. A comparison of performance and exhaust emissions with different valve lift profiles between gasoline and LPG fuels in a SI engine. Appl Therm Eng. 2016;107:1261-1268. https://doi.org/10.1016/j.appl....
5.
Faria MV, Varella RA, Duarte GO, Farias TL, Baptista PC. Engine cold start analysis using naturalistic driving data: City level impacts on local pollutants emissions and energy consumption. Sci Total Environ. 2018;630:544-559. https://doi.org/10.1016/j.scit....
6.
Frondel M, Marggraf C, Sommer S, Vance C. Reducing vehicle cold start emissions through carbon pricing: evidence from Germany. Environ Res Lett. 2021;16:034041. https://doi.org/10.1088/1748-9....
7.
Gao J, Tian G, Sorniotti A, Karci AE, Di Palo R. Review of thermal management of catalytic converters to decrease engine emissions during cold start and warm up. Appl Therm Eng. 2019;147:177-187. https://doi.org/10.1016/j.appl....
8.
Gong C, Yan S, Su Y, Wang Z. Effects of fuel injection timing on combustion and emissions of a spark-ignition methanol and methanol/liquefied petroleum gas (LPG) engine during cold start. Energy Fuels. 2009;23:3536-3542. https://doi.org/10.1021/ef9001....
9.
Gumus M. Reducing cold-start emission from internal combustion engines by means of thermal energy storage system. Appl Therm Eng. 2009;29:652-660. https://doi.org/10.1016/j.appl....
10.
Gumus M, Ugurlu A. Application of phase change materials to pre-heating of evaporator and pressure regulator of a gaseous sequential injection system. Appl Energ. 2011;88:4803-4810. https://doi.org/10.1016/j.apen....
11.
Gutierrez LG, Wooldridge MS, Petersen BR, Wooldridge ST. In-cylinder imaging and emissions measurements of cold-start split injection strategies. J Eng Gas Turbines Power. 2025;147:081014. https://doi.org/10.1115/1.4067....
12.
Hao L, Xu X, Guo X, Ji C, Wang X, Tan J et al. Investigation of cold-start emission control strategy for a bi-fuel hydrogen/gasoline engine. Int J Hydrogen Energ. 2016;41:18273-18281. https://doi.org/10.1016/j.ijhy....
13.
Hastie T, Tibshirani R, Friedman J. The elements of statistical learning. Springer New York 2009. https://doi.org/10.1007/978-0-....
14.
Henein NA, Tagomori MK. Cold-start hydrocarbon emissions in port-injected gasoline engines. Prog Energy Combust Sci. 1999;25:563-593. https://doi.org/10.1016/S0360-....
15.
Hu J, Frey HC, Boroujeni BY. Contribution of cold starts to real-world trip emissions for light-duty gasoline vehicles. Atmosphere. 2022;14:35. https://doi.org/10.3390/atmos1....
16.
Hu J, Li D, Hall M, Matthews R, Moilanen P, Wooldridge S et al. A parametric study to improve first firing cycle emissions of a gasoline direct injection engine during cold start. Int J Eng Res. 2023;24:3428-3444. https://doi.org/10.1177/146808....
17.
Hunicz J. An experimental study into the chemical effects of direct gasoline injection into retained residuals in a homogeneous charge compression ignition engine. Int J Eng Res. 2016;17:1031-1044. https://doi.org/10.1177/146808....
18.
James G, Witten D, Hastie T, Tibshirani R. An introduction to statistical learning: with applications in R. Springer 2021. https://doi.org/10.1007/978-1-....
19.
Jatana GS, Dal Forno Chuahy F, Szybist J. Effect of split-injection strategies on engine performance and emissions under cold-start operation. SAE Technical Paper 2023-01-0236. 2023. https://doi.org/10.4271/2023-0....
20.
Joshua Ikiaye D, Moore Ojapah M. Performance, emission and cost analysis of LPG and gasoline in a single cylinder engine. IJERSTE 2023;12:212-219. https://doi.org/10.55948/IJERS....
21.
Kim J, Choi K, Myung C-L, Park S. Experimental evaluation of engine control strategy on the time resolved THC and nano-particle emission characteristics of liquid phase LPG direct injection (LPG-DI) engine during the cold start. Fuel Process Technol. 2013;106:166-173. https://doi.org/10.1016/j.fupr....
22.
Kim K, Kim J, Oh S, Kim C, Lee Y. Lower particulate matter emissions with a stoichiometric LPG direct injection engine. Fuel. 2017;187:197-210. https://doi.org/10.1016/j.fuel....
23.
Kłosowski G, Rymarczyk T, Niderla K, Kulisz M, Skowron Ł, Soleimani M. Using an LSTM network to monitor industrial reactors using electrical capacitance and impedance tomography – a hybrid approach. Eksploat Niezawodn. 2023;25(1):11. https://doi.org/10.17531/ein.2....
24.
Kontses A, Triantafyllopoulos G, Ntziachristos L, Samaras Z. Particle number (PN) emissions from gasoline, diesel, LPG, CNG and hybrid-electric light-duty vehicles under real-world driving conditions. Atmos Env. 2020;222:117126. https://doi.org/10.1016/j.atmo....
25.
Kozłowski E, Borucka A, Oleszczuk P, Leszczyński N. Evaluation of readiness of the technical system using the semi-Markov model with selected sojourn time distributions. Eksploat Niezawodn. 2024;26. https://doi.org/10.17531/ein/1....
26.
Kwak H, Myung C-L, Park S. Experimental investigation on the time resolved THC emission characteristics of liquid phase LPG injection (LPLi) engine during cold start. Fuel. 2007;86:1475-1482. https://doi.org/10.1016/j.fuel....
27.
Laskowski P, Zasina D, Zimakowska-Laskowska M, Orliński P. Modelling hydrocarbons cold-start emission from passenger cars. Adv Sci Technol Res J. 2021;15:117-125. https://doi.org/10.12913/22998....
28.
Laskowski P, Zimakowska-Laskowska M, Matej J, Wiśniowski P. The problem of cold start emissions from vehicles. Combustion Engines. 2024;199(4):43-51. https://doi.org/10.19206/CE-18....
29.
Laskowski P, Zimakowska-Laskowska M, Zasina D. Modelling of the air pollutants’ cold-start emissions depending on average vehicles’ speed. Combustion Engines. 2022;188:96-103. https://doi.org/10.19206/CE-14....
30.
Lee K, Pintor DL, Assanis D, Cho S, Hwang J. Fuel temperature and injection pressure influence on the cold start GDI sprays. Appl Energy Combust Sci. 2023;16:100206. https://doi.org/10.1016/j.jaec....
31.
Liu F, Shafique M, Luo X. Literature review on life cycle assessment of transportation alternative fuels. Environ Technol Innov. 2023;32:103343. https://doi.org/10.1016/j.eti.....
32.
Liu H, Liu Q, Wang C. A novel valve strategy for particulate matter reduction in a gasoline direct injection engine operated at cold conditions. Int J Engine Res. 2025;26:325-338. https://doi.org/10.1177/146808....
33.
Liu Z, Li L, Deng B. Cold start characteristics at low temperatures based on the first firing cycle in an LPG engine. Energy Convers Manag. 2007;48:395-404. https://doi.org/10.1016/j.enco....
34.
Ludykar D, Westerholm R, Almén J. Cold start emissions at +22, −7 and −20°C ambient temperatures from a three-way catalyst (TWC) car: regulated and unregulated exhaust components. Sci Total Environ. 1999;235:65-69. https://doi.org/10.1016/S0048-....
35.
Małek A, Caban J, Sarkan B. Research on low-emission vehicle powered by LPG using innovative hardware and software. The Archives of Automotive Engineering – Archiwum Motoryzacji. 2020;89:19-36. https://doi.org/10.14669/AM.VO....
36.
Myung C-L, Kim J, Choi K, Hwang IG, Park S. Comparative study of engine control strategies for particulate emissions from direct injection light-duty vehicle fueled with gasoline and liquid phase liquefied petroleum gas (LPG). Fuel. 2012;94:348-355. https://doi.org/10.1016/j.fuel....
37.
Napolitano P, Alfè M, Guido C, Gargiulo V, Fraioli V, Beatrice C. Particle emissions from a HD SI gas engine fueled with LPG and CNG. Fuel. 2020;269:117439. https://doi.org/10.1016/j.fuel....
38.
Pawlik P, Kania K, Przysucha B. Fault diagnosis of machines operating in variable conditions using artificial neural network not requiring training data from a faulty machine. Eksploat Niezawodn. 2023;25. https://doi.org/10.17531/ein/1....
39.
Reiter MS, Kockelman KM. The problem of cold starts: A closer look at mobile source emissions levels. Transp Res Part D Transp Environ. 2016;43:123-132. https://doi.org/10.1016/j.trd.....
40.
Saliba G, Saleh R, Zhao Y, Presto AA, Lambe AT, Frodin B et al. Comparison of gasoline direct-injection (GDI) and port fuel injection (PFI) vehicle emissions: emission certification standards, cold-start, secondary organic aerosol formation potential, and potential climate impacts. Environ Sci Technol. 2017;51:6542-6552. https://doi.org/10.1021/acs.es....
41.
Šarkan B, Jaśkiewicz M, Kubiak P, Tarnapowicz D, Loman M. Exhaust emissions measurement of a vehicle with retrofitted LPG system. Energies. 2022;15:1184. https://doi.org/10.3390/en1503....
42.
Sharma NK. Comparison of spark ignition engine performance and emission analysis using gasoline, LPG and mixture fuels. IJMTST. 2020;6:33-36. https://doi.org/10.46501/IJMTS....
43.
Talib Hashem G, Al-Dawody MF, Sarris IE. The characteristics of gasoline engines with the use of LPG: an experimental and numerical study. Int J Thermofluids. 2023a;18:100316. https://doi.org/10.1016/j.ijft....
44.
Talib Hashem G, Al-Dawody MF. Use of LPG in SI engine – a review study. Al-Qadisiyah J Eng. 2021;14(1):52-59, https://doi.org/10.30772/qjes.....
45.
Tan D, Wang Y, Tan J, Li J, Wang C, Ge Y. Influence of ambient temperature on the CO2 emitted of light-duty vehicle. J Environ Sci. 2024;140:59-68. https://doi.org/10.1016/j.jes.....
46.
Teymoori MM, Chitsaz I, Kashani NA, Davazdah Emami M. Cold-start emission reduction of the gasoline-powered vehicle utilizing a novel method. Int J Engine Res. 2023;24:1840-1859. https://doi.org/10.1177/146808....
47.
Usman M, Farooq M, Naqvi M, Saleem MW, Hussain J, Naqvi SR et al. Use of gasoline, LPG and LPG-HHO blend in SI engine: a comparative performance for emission control and sustainable environment. Processes. 2020;8:74. https://doi.org/10.3390/pr8010....
48.
Weilenmann M, Favez J-Y, Alvarez R. Cold-start emissions of modern passenger cars at different low ambient temperatures and their evolution over vehicle legislation categories. Atmos Environ. 2009;43:2419-2429. https://doi.org/10.1016/j.atmo....
49.
Woo Jeong J, Baek S, Park S, Lee S, Lim Y, Lee K. Trends in NOx and NH3 emissions caused by three-way catalysts. Fuel. 2024;366:131282. https://doi.org/10.1016/j.fuel....
50.
Worsztynowicz B, Uhryński A. The analysis of heating process of catalytic converter using thermo-vision. Combustion Engines. 2015;162:41-51. https://doi.org/10.19206/CE-11....
51.
Yusuf AA, Inambao FL. Effect of cold start emissions from gasoline-fueled engines of light-duty vehicles at low and high ambient temperatures: recent trends. Case Stud Therm Eng. 2019;14:100417. https://doi.org/10.1016/j.csit....
52.
Zhang B, Li X, Wan Q, Liu B, Jia G, Yin Z. Hydrocarbon emission control of an adsorptive catalytic gasoline particulate filter during cold-start period of the gasoline engine. Energy. 2023;262:125445. https://doi.org/10.1016/j.ener....
53.
Zhang Z, Man H, Zhao J, Jiang Y, Zeng M, Cai Z, et al. Primary organic gas emissions in vehicle cold start events: Rates, compositions and temperature effects. J Hazard Mater. 2022;435:128979. https://doi.org/10.1016/j.jhaz....
54.
Zhang Z, Zhong W, Tan D, Cui S, Pan M, Zhao Z et al. Hydrocarbon adsorption mechanism of modern automobile engines and methods of reducing hydrocarbon emissions during cold start process: a review. J Environ Manage. 2024;353:120188. https://doi.org/10.1016/j.jenv....
55.
Zimakowska-Laskowska M, Kozłowski E, Laskowski P, Wiśniowski P, Świderski A, Orynycz O. Vehicle exhaust emissions in the light of modern research tools: synergy of chassis dynamometers and computational models. Combustion Engines. 2025;200:145-154. https://doi.org/10.19206/CE-20....
| eISSN: | 2658-1442 |
| ISSN: | 2300-9896 |
The scientific journal is financed under the Agreement 185/WCN/2019/1 from the funds of the Minister of Science and Higher Education
© 2006-2026 Journal hosting platform by Bentus
We process personal data collected when visiting the website. The function of obtaining information about users and their behavior is carried out by voluntarily entered information in forms and saving cookies in end devices. Data, including cookies, are used to provide services, improve the user experience and to analyze the traffic in accordance with the Privacy policy. Data are also collected and processed by Google Analytics tool (more).
You can change cookies settings in your browser. Restricted use of cookies in the browser configuration may affect some functionalities of the website.
You can change cookies settings in your browser. Restricted use of cookies in the browser configuration may affect some functionalities of the website.
